Kawasaki Ninja Service Manual: DFI System Troubleshooting Guide

Kawasaki Ninja Service Manual / Fuel System (DFI) / DFI System Troubleshooting Guide

NOTE

This is not an exhaustive list, giving every possible cause for each problem listed. It is meant simply as a rough guide to assist the troubleshooting for some of the more common difficulties in DFI system.
The ECU may be involved in the DFI electrical and ignition system troubles. If these parts and circuits are checked out good, be sure to check the ECU for ground and power supply. If the ground and power supply are checked good, replace the ECU.

Engine Won’t Turn Over

Engine Won’t Turn Over

Poor Running at Low Speed

Poor Running at Low Speed

Poor Running or No Power at High Speed

Poor Running or No Power at High Speed

Inquiries to Rider

DFI Diagnosis Flow Chart Each rider reacts to problems in different ways, so it is important to confirm what kind of symptoms the rider has encountered. Try to find out exactly what pro ...

Warning Indicator Light (LED)

Light (LED) Inspection The warning indicator light (LED) [A] is used for the FI indicator, immobilizer indicator (immobilizer equipped models), water temperature warning indicator and oil pres ...

Other materials:

Parts Removal/Installation
WARNINGGasoline is extremely flammable and can be explosive under certain conditions. Turn the ignition switch OFF. Do not smoke. Make sure the area is well-ventilated and free from any source of flame or sparks; this includes any appliance with a pilot light. NOTICE ...

Battery Installation
Visually inspect the surface of the battery container. If any signs of cracking or electrolyte leakage from the sides of the battery. Put the battery into the rear fender Install the band [A]. Connect the positive (+) cable [B] (red cap) to the positive (+) terminal first, and then ...

Front Fork Inspection
Holding the brake lever, pump the front fork up and down several times to inspect smooth stroke. Visually inspect the front fork for oil leakage, scoring or scratches on the outer surface of the inner tube. If any doubt about the front fork, it should be checked by an authorized K ...